hi guys,
having a bit of trouble with my scottoiler vSystem that i just fitted and cant seem to set up right, ive got it set to 1 drop a minute like it says but it still decided to spunk all over the tyre wall and a few bits on the contact surface off the tyre.
naturally i adhusted it some more and still too much commin out even tho ive only got i tad left on the adjuster.

Puzzled?

__________________
...On a steel horse i ride.

There are a couple of things;

1) the oil flows more during warmer weather, so the same setting one week might well let more oil through the next.

2) Two types of oil, blue oil for cool/cold weather and red oil for warm weather. Red oil is thicker and flows slower in hot weather.

Scottoilers are brilliant money saving gizmo's, but you do have to keep on top of the adjustment.

knock it back a notch and keep an eye on the flow, if it looks too much, then knock it back again. As the weather cools (into winter) start to increase the flow.

You will always get some splatter, that's a big plus point of the system, it washes away crud/crap/salt/sand etc - better than a new chain & sprocket every 10,000 miles.

08 Tenere, still on original chain & sprocket after 24k miles.......

__________________
>-------<

Never underestimate the power of stupid people in large groups.

nice one i think ive sussed it, just gonna check it every other ride.

__________________
...On a steel horse i ride.

Where is the best place to put the chamber? Under the seat or on the frame or under the rear rack?

__________________
Ride hard, Fall Softly. [SIGPIC][/SIGPIC]

right side of frame, near the rear brake res' use the frame block to mount.

__________________
...On a steel horse i ride.

I thank you !

__________________
Ride hard, Fall Softly. [SIGPIC][/SIGPIC]

hi has anyone got some pics of a scottoiler in place on an XT660x by any chance as I'm thinking of fitting one but want to see how people have theirs setup first if possible

thanks

__________________
2004-2006 Yamaha R603 plate Akra carbon can Ohlins steering damper carbon air intakes/rear fender/hugger double bubble race screen YM600 cycle lock LED indicators tail tidy
2009 - 2009 Yamaha R657 plate with titanium Akra full exhaust system ASV short levers Carbon fuel tank/front fender/rear hugger Ohlins steering damper LED indicators, double bubble race screen
2011 - now Yamaha XT660X 56 plate mtc cans 2b contd...

Timboo, hope this helps

__________________


Dog Tired

Actually ... I got rid of the scottoiler quite some time ago.

I suspect that the single cilinder vacuum pulses make it hard to tune the oil flow. I did use the red oil: the blue oil almost flushed through!

I do ride off-road/unpaved roads quite a lot and sand combined with too much oil make a nice grinding paste...

... so I returned to the occasional (once in 500km) manual chain lubrication and chain life went up to almost 20,000km's , instead of 15.000km.

HJ

__________________
Riding the Mad Mule !! ... no more... went orange...

I found the opposite, traditional thick chain lube with sand and dirt turned into an even thicker grinding paste. The thin Scotoil never stuck to anything, except to the wheel rims and the underside of the rear mud guard. In sand and off road the setting just needed to be turned up a bit.

Rob